xz防水层及沉降缝处理技术交底文档格式.docx
- 文档编号:16505808
- 上传时间:2022-11-24
- 格式:DOCX
- 页数:17
- 大小:34.83KB
xz防水层及沉降缝处理技术交底文档格式.docx
《xz防水层及沉降缝处理技术交底文档格式.docx》由会员分享,可在线阅读,更多相关《xz防水层及沉降缝处理技术交底文档格式.docx(17页珍藏版)》请在冰豆网上搜索。
根据《铁路混凝土桥涵防水层》【二设桥参(土一)(2009)6002】以及相关技术交底要求现将涵洞工程防水层及沉降缝处理施工有关要求交底与你工班,请遵照执行。
技术说明:
1、聚氨酯防水涂料说明:
(1)甲种防水层:
甲料18kg/桶包装,乙料18kg/桶包装;
按甲料1桶乙料2桶配比;
使用前先打开乙料充分搅匀后倒入甲料,再搅匀后即可使用。
如果粘贴卷材,先涂刷第一遍,等干固后可涂刷第二遍,待有一定粘性后即可粘贴卷材,粘贴后用手压实。
(2)丙种防水层:
甲料10kg/桶包装,乙料15kg/桶包装;
按甲料1桶乙料2桶配比。
2、有未尽详细事宜及时与技术员联系。
注意事项:
一、涵洞工程防水层分类、构成及其适用范围
1、分类:
涵洞工程防水层分为TQF甲种防水层和TQF丙种防水层。
2、构成:
(1)TQF甲种防水层由氯化聚乙烯防水卷材和TQF-Ⅱ聚氨酯防水涂料共同构成。
(2)TQF丙种防水层由TQF-881聚氨酯防水涂料构成。
即需在设防水层的混凝土上涂刷TQF-881聚氨酯防水涂料,涂料总涂抹厚度不得小于2mm,每平方米用量约2.4kg。
3、适用范围:
(1)TQF甲种防水层:
A、适用于板顶填土高度小于等于1.0m的框架桥、框架涵(含顶进桥、涵)和盖板箱涵的盖板顶面及盖板底面线以下0.2m之两侧边墙外侧的防水层设置;
B、适用于各类框架桥、框架涵(含顶进桥、涵)、盖板箱涵的沉降缝的防水层设置(5cm宽)。
(2)TQF丙种防水层:
A、适用于板顶填土高度大于1.0m的框架桥、框架涵(含顶进桥、涵)及盖板箱涵之盖板顶面的防水层设置;
B、适用于框架桥结构底面和侧面、框架涵及盖板箱涵涵身边墙外侧的防水层设置。
二、施工工艺及要求:
(一)结构混凝土基层表面处理
1、防水层施工前结构混凝土的基层面应保证平整、干净、干燥、无凹凸不平、蜂窝及麻面,平整度用1m靠尺检查,空隙允许平缓变化,但不得大于3mm。
2、对蜂窝、麻面作填补前,应清除蜂窝、麻面中的松散层、浮渣、浮土、油污等,并使之湿润,再用M10水泥砂浆填补平整。
对蜂窝、麻面的填补,均应在水泥砂浆、水泥净浆中添加类似107胶的水溶性胶粘剂以增强水泥砂浆、水泥净浆和基层面的连接。
3、防水层铺设时应清除混凝土表面浮浆和灰尘,混凝土基层面不得积水,应保持干净。
(二)防水层铺设
1、防水卷材加粘贴防水涂料型防水层(TQF型甲种防水层)
(1)防水卷材纵向宜整体铺设,当防水卷材进行搭接时,先有纵向搭接,再进行横向搭接,纵向搭接接头应错开。
防水卷材应顺上坡方向逐幅铺设,其纵向搭接长度不得小于120mm,横向搭接宽度不得小于80mm。
(2)防水卷材的铺设要严密,表面平整,无歪斜,无皱折,无鼓泡,无接口不严或边缘翘起现象。
(3)搭接处应粘贴牢固,两层防水卷材之间的涂料厚度不得小于1mm。
2、无需防水卷材的涂料型防水层(TQF型丙种防水层)
(1)聚氨酯防水涂料总涂抹厚度不得小于2.0mm,每平方米用量约2.4kg。
(2)基层表面不得有明水,严禁雨中施工。
(3)施作要求:
A、宜采用喷涂设备将涂料均匀喷涂于基层表面,也可采用金属锯齿板(应保证涂抹厚度达到2.0mm)将涂料均匀涂刷于基层表面。
B、涂料主剂(甲组分)、固化剂(乙组分)须按产品说明进行配制,每种组分的称量误差不得大于±
2%。
C、采用人工涂刷配制涂料时,按照先主剂、后固化剂的顺序将液体倒入容器,并充分搅拌使其均匀,搅拌时间约3—5分钟。
D、搅拌时不得加水,必须采用机械方法搅拌,搅拌器的转速宜在200—300转/分。
E、涂刷应分两次进行,以防止气泡存于涂膜内。
第一次适用平板在基面上刮涂一层厚度0.2mm左右的涂膜,1~2小时内使用金属锯齿板进行第二次刮涂。
F、配制好的涂料应在20分钟内完成,随配随用。
G、对涵洞竖墙等垂直部位使用毛刷或辊子先行涂刷,平面部分在其后涂刷。
H、不得使用风扇或类似工具缩短干燥时间。
I、喷涂后4小时或涂刷后12小时内须防止霜冻、雨淋及暴晒。
防水层完全干固后,方可浇筑保护层。
J、防水层铺设施工环境温度不得低于5℃。
(三)保护层
对填土高度大于1.0m的涵洞,在防水层完全固化后,须在防水层的外侧包一层15~20cm厚不透水粘土作成通长保护层(在缺乏不透水粘土时,15~20cm厚不透水保护层可免做);
对填土高度小于等于1.0m的涵洞,以C40细石聚丙烯纤维网混凝土保护层和通长不透水土壤保护层组合构成,组合方式见附图。
(四)沉降缝
1、沉降缝所用TQF甲种防水带、TQF-881聚氨酯防水涂料浸制麻绳、中间填塞粘土、M10水泥砂浆、TQF-881聚氨酯防水涂料浸制木板的品种、规格、性能等必须符合设计要求;
2、沉降缝位置、尺寸、构造形式和止水带的安装等必须符合设计要求;
3、沉降缝不得漏水;
4、沉降缝填塞前,缝内应先清扫干净,保持干燥,不得有杂物和积水;
5、沉降缝的表面质量应达到缝宽均匀,缝身竖直,环向贯通,填塞密实,外表光洁。
三、质量检查
1、防水卷材应涂刷均匀,无漏刷、无气泡。
铺设完成用橡胶测厚仪检查涂层厚度。
2、防水卷材的铺设应平整、无破损、无空鼓,搭接处及周边均不得翘起。
保护层表面不得出现裂缝。
3、两幅防水卷材铺贴完毕,用防水涂料进行封边,封边时,防水卷材的周边往里80mm应涂刷防水涂料,其涂刷厚度均不得低于1.5mm。
四、其他
1、防水卷材及防水涂料等材料的运输及保存应严格按照生产厂家的要求办理。
严禁遇水,严禁接近火源。
2、四级以上的强风天气不宜进行防水层的施工。
3、环境温度低于10℃时,应采取保温措施。
为改善聚氨酯防水涂料的稠度,可用间接蒸汽预热,降低涂料的稠度,两个组分应分开加热,加热温度不得超过60℃,同时须保证蒸汽不得加入涂料中。
严禁明火加热。
4、涂料运至施工现场,若涂料离析、结块则不得施工。
5、施工时涂料不得敞口放置,用后及时将容器盖拧紧、拧严。
附:
1、涵洞沉降缝及防水层处理示意图;
2、涵洞沉降缝、防水层工程数量及路基填土高度统计表。
复核者:
签收者:
签收时间:
(英文版)
Tworegulationspromulgatedforimplementationisinthepartyinpowerforalongtimeandtheruleoflawconditions,theimplementationofcomprehensivestrictlystrategicplan,implementationinaccordancewiththerulesanddisciplinetomanagetheparty,strengtheninner-partysupervisionofmajorinitiatives.Thetworegulationssupportingeachother,the<
code>
adheretoapositiveadvocate,focusingonmoralityisofPartymembersandPartyleadingcadrescansee,enoughtogetahighstandard;
<
rule>
aroundthepartydiscipline,disciplinaryrulerrequirements,listedas"
negativelist,focusingonverticalgauge,drawthepartyorganizationsandPartymembersdonottouchthe"
bottomline"
.Here,themainfromfoursquarefacetwopartyrulesofinterpretation:
thefirstpartintroducestwopartyRevisedregulationsthenecessityandtherevisionprocess;
thesecondpartistheinterpretationofthetwofundamentalprinciplesoftherevisionoflawsandregulationsintheparty;
thethirdpartintroducestwopartyregulationsmodifiedthemainchangesandneedstograspseveralkeyproblems;
thefourthpartonhowtograsptheimplementationofthetworegulationsoftheparty.<
and<
Regulations>
revisedthenecessityandrevisedhistoryoftheCPCCentralCommitteetheamendmenttotheChineseCommunistPartymembersandleadingcadreshonestpoliticsseveralguidelines>
ChineseCommunistPartydisciplineandPunishmentRegulations>
column1by2015tostrengthenpartylawsandregulationsfocus.TwopartyregulationsrevisionworklastedaYears,poolingthewisdomofthewholeparty,ideologicalconsensus,drawhistoricalexperience,respectforthewisdomofourpredecessors,whichreflectstheunityofinheritanceandinnovation;
followthecorrectdirection,graspthelimitedgoals,adheretotheparty'
sleadership,tosolvethemassesofthepeoplereflectafocusontheproblem.Thenewrevisionofthe<
reflectstheparty'
s18andtheeighthsessionofthethird,thespiritofthefourthplenarysession,reflectingtheexperienceofstudyingandimplementingtheGeneralSecretaryXiJinpingseriesofimportantspeech,reflectstheparty'
seighteenyearscomprehensivestrictlypractice.(a)revisedtworegulationsofthepartyneedof<
theICACguidelines>
in<
in1997LeadersasmembersoftheCommunistPartyofChinacleanpoliticscertaincriteria(Trial)>
basedonrevised,thepromulgationandimplementationofJanuary2010,tostrengthentheconstructionofthecontingentofleadingcadresplayanimportantrole.Butwiththepartytomanagethepartystrictlyadministeringthedeepening,hasnotbeenabletofullymeettheactualneeds.Contentistoocomplicated,"
eightprohibition,52arenotallowedto"
hardtoremember,andalsodifficulttoputintopractice;
thesecondisconciselypositiveadvocatedbythelackofprohibitedprovisionsexcessive,noautonomyrequirements;
thethirdisbannedtermsanddisciplinelaw,bothwiththepartydiscipline,disciplinaryregulationsrepeatandCriminallawandotherlawsandregulationsrepeat;
thefourthisto"
clean"
thethemeisnotprominent,notfortheexistingproblems,andisnarrow,onlyneedleofcounty-levelleadingcadresabove.<
isin1997<
ChineseCommunistPartydisciplinarycases(Trial)>
basedonrevision,inDecember2003thepromulgationandimplementation,tostrengthentheconstructionofthepartyplayveryimportantrole.Alongwiththedevelopmentofthesituation,whichmanyprovisionshavebeenunabletofullymeetthecomprehensivestrictlyadministeringthepracticeneeds.OneisJilaw,morethanhalfoftheprovisionsandcriminallawandothercountrieslawsandregulationsRepetition;
twoisthepoliticaldisciplineregulationsisnotprominent,notspecific,forviolationofthepartyconstitution,damagetheauthorityofPartyConstitutionofmisconductlacknecessaryandseriousresponsibilitytopursue;
thirdisthemaindisciplinefortheleadingcadres,doesnotcoverallPartymembers.Basedontheabovesituation,needto<
thecriterionofacleanandhonestadministration>
thetwoislikelytobemorerelevantregulationsfirstamendment.Byrevising,reallyputtheauthorityofPartydiscipline,theseriousnessinthepartytreeandcallupthemajorityofPartymembersandcadresofthepartyconstitutionofpartycompassespartyconsciousness.(II)twopartyregulationsrevisionprocesstheCentralCommitteeoftheCommunistPartyofChinaattachesgreatimportancetotworegulationsrevision.XiJinping,generalbooksrecordedintheFifthPlenarySessionoftheeighthsessionoftheCentralCommissionforDisciplineInspection,ontherevisedregulations<
>
madeclearinstructions.Accordingtothecentraldeployment,theCentralCommissionforDisciplineInspectionfrom2014undersixmonthsbeginstudytworegulationsrevision.TheStandingCommitteeoftheCentralCommissionforDisciplineInspection4reviewrevised.ComradeWangQishan14timesheldaspecialmeetingtostudytworegulationsrevision,amendmentclarifiesthedirection,majorissuesofprinciple,pathandtarget,respectivelyheldaforumwilllistentopartoftheprovince(area)secretaryofthePartycommittee,SecretaryoftheDisciplineInspectionCommission,partofthecentralministriesandstateorgansDepartment
Thefirstpartycommitteeismainlyresponsibleforpeople,viewsofexpertsandscholarsandgrassrootspartyorganizationsandPartymembers.ApprovedbytheCentralCommitteeoftheCommunistPartyofChina,on7September2015,thegeneralofficeoftheCentralCommitteeofthePartyissuedanoticetosolicittheprovinces(autonomousregions,municipalities)Party,thecentralministriesandcommissions,stateministriesandcommissionsoftheParty(party),theGeneralPoliticalDepartmentofthemilitary,every3peopleorganizationofPartyoftworegulationsrevisionopinion.CentralCommissionforDisciplineInspectionofextensivesolicitationofopinions,carefulstudy,attracting,formedarevisedsentreviewers.InOctober8andOctober12,CentralCommitteePoliticalBureauStandingCommitteeandthePoliticalBureauoftheCentralCommitteeAfterconsiderationofthetworegulationsreviseddraft.OnOctober18,theCentralCommitteeoftheCommunistPartyofChinaformallyissuedtworegulations.Cansay,twolawsamendmentconcentratedthewisdomofthewholeparty,embodiestheparty.Second,<
revisionofthebasicprinciplesoftwopartyregulationsrevisionworkandimplementtheparty'
seighteen,teneightplenary,thespiritoftheFourthPlenarySessionoftheEleventhCentralCommitteeandGeneralSecretaryXiJinpingimportantinstructionsontherevised<
lowpoliticalcriterion>
highlightingtherulingpartycharacteristics,seriousdiscipline,thedisciplinequiteinfrontofthelaw,basedonthecurrent,along-term,advanceasawhole,withBuXiudingindependent<
.Mainprincipleis:
first,adheretothepartyconstitutiontofollow.Thecon
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- xz 防水层 沉降 处理 技术 交底