qo一次风机二次风机和侧墙冷却风机技术要求.docx
- 文档编号:23872194
- 上传时间:2023-05-21
- 格式:DOCX
- 页数:27
- 大小:54.03KB
qo一次风机二次风机和侧墙冷却风机技术要求.docx
《qo一次风机二次风机和侧墙冷却风机技术要求.docx》由会员分享,可在线阅读,更多相关《qo一次风机二次风机和侧墙冷却风机技术要求.docx(27页珍藏版)》请在冰豆网上搜索。
qo一次风机二次风机和侧墙冷却风机技术要求
济南市第二生活
垃圾综合处理厂焚烧发电厂
焚烧间一、二次风机和侧墙冷却风机
招标技术参数
2009年6月
1.工程概况:
项目名称:
济南市第二生活垃圾综合处理厂焚烧发电厂
项目建设单位:
光大环保工程技术(深圳)有限公司
本项目位于济南市济阳县孙耿镇香火高家村南侧园地,日焚烧处理生活垃圾2000吨,配置4台500t/d炉排型垃圾焚烧炉,年焚烧垃圾66.67万吨。
2.主要原始资料
2.1气象特征与环境条件
年平均气温:
13.6℃,最高气温42.7℃,最低气温:
-19.7℃
年平均积雪日数14.7天,最大积深19cm。
降雨量:
年平均降雨量:
685mm
年最大降雨量:
1160mm
年最小降雨量:
320.7mm
湿度:
年平均相对湿度58%
风向风速:
常年主导风向:
西南、东北风
最大风速:
33.3m/s,风力12级以上。
无霜期:
全年无霜期:
230天左右
2.2地震烈度
地震烈度:
6度
设计基本地震加速度值为0.05g
3.风机技术参数:
3.1设备名称:
#1~#4一次风机
工作制度:
连续运行,全年运行至少8000h
数量:
共32台(每条焚烧线8台)
风机类型:
离心风机
技术规格
额定工况(MCR)
最大工况(MR)
1
风量(Nm³/h)
5.178-7.358
9.810
风量(m³/h)
9.395-13.420
18.037
2
入口静压(Pa(g))
-510/-1030
-1830
3
出口静压(Pa(g))
360/730
1310
4
静压差(Pa)
870/1760
3130
5
工作温度(℃)
220
5~235
6
环境湿度(%)
70
5~95%
7
安装地点
焚烧间
8
风机转速(rpm)
≤3000
9
风机效率(%)
80
10
噪音等级(dB(A))
≤82(距离设备1m外)
11
控制方式
变频控制
12
绝缘/防护等级
F(Class/IP54)
13
电源(V/Ph/Hz)
400/3+N+E/50
14
电机功率(kW)
30
15
振动要求
至少Q6,3
16
吸风口方向:
水平方向吸风
17
出风口方向:
8台左旋90°垂直向上出风
8台右旋90°垂直向上出风
3.2设备名称:
#5一次风机
工作制度:
连续运行,全年运行至少8000h
数量:
共8台(每条焚烧线2台)
风机类型:
离心风机
技术规格
额定工况(MCR)
最大工况(MR)
1
风量(Nm³/h)
2180
5450
风量(m³/h)
3947
10015
2
入口静压(Pa(g))
-280
-1770
3
出口静压(Pa(g))
170
1040
4
静压差(Pa)
450
2810
5
工作温度(℃)
220
5~235
6
环境湿度(%)
70
5~95%
7
安装地点
焚烧间
8
风机转速(rpm)
≤3000
9
风机效率(%)
≥75
10
噪音等级(dB(A))
≤82(距离设备1m外)
11
控制方式
变频控制
12
绝缘/防护等级
F(Class/IP54)
13
电源(V/Ph/Hz)
400/3+N+E/50
14
电机功率(kW)
15
15
振动要求
至少Q6,3
16
吸风口方向:
水平方向吸风
17
出风口方向:
2台左旋90°垂直向上出风
2台右旋90°垂直向上出风
3.3设备名称:
二次风机
工作制度:
连续运行,全年运行至少8000h
数量:
共4台(每条焚烧线1台)
风机类型:
离心风机
技术规格
额定工况(MCR)
最大工况(MR)
1
风量(Nm³/h)
16640
31275
风量(m³/h)
1882
35683
2
入口静压(Pa(g))
-270
-1140
3
出口静压(Pa(g))
1770
7320
4
静压差(Pa)
2040
8460
5
工作温度(℃)
35
5~45
6
环境湿度(%)
70
5~95%
7
安装地点
焚烧间
8
风机转速(rpm)
≤3000
9
风机效率(%)
≥80
10
噪音等级(dB(A))
≤82(距离设备1m外)
11
控制方式
变频控制
12
绝缘/防护等级
F(Class/IP54)
13
电源(V/Ph/Hz)
400/3+N+E/50
14
电机功率(kW)
160
15
振动要求
至少Q6,3
16
吸风口方向:
水平方向吸风
17
出风口方向:
右旋90°垂直向上出风
3.4设备名称:
侧墙冷却风机
工作制度:
连续运行,全年运行至少8000h
数量:
共4台(每条焚烧线1台)
风机类型:
离心风机
技术规格
额定工况(MCR)
最大工况(MR)
1
风量(Nm³/h)
6000
13335
2
静压差(Pa)
2240
11050
3
工作温度(℃)
35
5~45
4
环境湿度(%)
70
5~95%
5
安装地点
焚烧间
6
风机转速(rpm)
≤3000
7
风机效率(%)
≥80
8
噪音等级(dB(A))
≤82(距离设备1m外)
9
控制方式
变频控制
10
绝缘/防护等级
F(Class/IP54)
11
电源(V/Ph/Hz)
400/3+N+E/50
12
振动要求
至少Q6,3
13
电机功率(kW)
75
14
吸风口方向:
水平方向吸风
15
出风口方向:
左旋180°水平出风
4.其他要求:
4.1以上风机尺寸必须提交KSBE批准。
4.2以上风机的其他技术参数由设备厂家完善并提交KSBE批准。
4.3所有风机需配带进出口膨胀节。
(英文版)
Tworegulationspromulgatedforimplementationisinthepartyinpowerforalongtimeandtheruleoflawconditions,theimplementationofcomprehensivestrictlystrategicplan,implementationinaccordancewiththerulesanddisciplinetomanagetheparty,strengtheninner-partysupervisionofmajorinitiatives.Thetworegulationssupportingeachother,theadheretoapositiveadvocate,focusingonmoralityisofPartymembersandPartyleadingcadrescansee,enoughtogetahighstandard;
thefirstpartintroducestwopartyRevisedregulationsthenecessityandtherevisionprocess;thesecondpartistheinterpretationofthetwofundamentalprinciplesoftherevisionoflawsandregulationsintheparty;thethirdpartintroducestwopartyregulationsmodifiedthemainchangesandneedstograspseveralkeyproblems;thefourthpartonhowtograsptheimplementationofthetworegulationsoftheparty.and
and
Thefirstpartycommitteeismainlyresponsibleforpeople,viewsofexpertsandscholarsandgrassrootspartyorganizationsandPartymembers.ApprovedbytheCentralCommitteeoftheCommunistPartyofChina,on7September2015,thegeneralofficeoftheCentralCommitteeofthePartyissuedanoticetosolicittheprovinces(autonomousregions,municipalities)Party,thecentralministriesandcommissions,stateministriesandcommissionsoftheParty(party),theGeneralPoliticalDepartmentofthemilitary,every3peopleorganizationofPartyoftworegulationsrevisionopinion.CentralCommissionforDisciplineInspectionofextensivesolicitationofopinions,carefulstudy,attracting,formedarevisedsentreviewers.InOctober8andOctober12,CentralCommitteePoliticalBureauStandingCommitteeandthePoliticalBureauoftheCentralCommitteeAfterconsiderationofthetworegulationsreviseddraft.OnOctober18,theCentralCommitteeoftheCommunistPartyofChinaformallyissuedtworegulations.Cansay,twolawsamendmentconcentratedthewisdomofthewholeparty,embodiestheparty.Second,and
first,adheretothepartyconstitutiont
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- qo 一次 风机 二次 冷却 技术 要求